Login
My Garage
  1. Home
  2. Recalls
  3. Toyota Avensis

Toyota Avensis Recalls

There are currently 85 safety recalls out on the Toyota Avensis. To find out whether your car is affected, you'll need to find your car's VIN number.

How to find your VIN

The VIN can often be found on the lower-left corner of the dashboard, in front of the steering wheel.

You can read the number by looking through the windshield. The VIN may also appear in a number of other locations:

  • Front of the engine block. This should be easy to spot by opening the bonnet, and looking at the front of the engine.
  • Front of the car frame, near the container that holds windshield washer fluid.
  • Rear wheel well. Try looking up, directly above the tyre.
  • Inside the driver-side doorjamb. Open the door, and look underneath where the side-view mirror would be located if the door was shut.
  • Driver-side doorpost. Open the door, and look near the spot where the door latches, not too far from the seatbelt return.
  • Underneath the spare tyre.
VIN Location Diagram

If you still can't locate the VIN, try consulting your vehicle manual. Or, call a dealership or the manufacturer and request guidance.

Step 2 - See if your car is affected
  • Announcement date:
    23/01/2023
    Recalls number:
    R/2022/346
    Car Build Date:
    22/08/2002 - 24/04/2006
    Concern:
    Driver's Air Bag Inflator May Rupture Upon Deployment.
    Defect:
    Driver's air bag inflator may rupture upon deployment.
    Remedy:
    Replace the drivers air bag assembly.
  • Announcement date:
    31/05/2021
    Recalls number:
    R/2021/104
    Car Build Date:
    06/05/2015 - 04/05/2018
    Concern:
    There Is A Possibility That The Exhaust Gas Recirculation Cooler Could Develop An Internal Coolant Leak
    Defect:
    A possibility that the Exhaust Gas Recirculation (EGR) cooler could develop an internal coolant leak
    Remedy:
    Replace the EGR cooler in all involved vehicles and if necessary replace the inlet manifold.
  • Announcement date:
    25/02/2019
    Recalls number:
    R/2018/378
    VIN start:
    0E001077-0E025810
    VIN end:
    0E001565-0E022682
    Car Build Date:
    11/05/2015 - 13/03/2018
    Concern:
    Incorrect Tightening Torque Was Possibly Applied During Previous Injector Removal Or Replacement
    Defect:
    An incorrect tightening torque was applied at the moment of injector re-installation.
    Remedy:
    Check the injector clamp bolt torque and replace the parts if necessary.
  • Announcement date:
    21/01/2019
    Recalls number:
    R/2018/340
    Car Build Date:
    28/01/2008 - 22/04/2015
    Concern:
    A Potential Crack Could Develop In The Fuel Evaporative Emission Control Unit Mounted In The Fuel Tank
    Defect:
    Possible fuel leak from fuel tank.
    Remedy:
    Replace the fuel tank emission control Canister.
  • Announcement date:
    17/12/2018
    Recalls number:
    R/2018/307
    VIN start:
    0E001005-0E161510
    VIN end:
    0E001007-0E161621
    Car Build Date:
    28/01/2003 - 21/04/2006
    Concern:
    Front Passenger Air Bag Inflators Containing Degraded Propellant May Result In An Inflator Rupture
    Defect:
    Passenger air bag may cause injury if activated.
    Remedy:
    Replace affected air bag assembly.
  • Announcement date:
    17/12/2018
    Recalls number:
    R/2018/306
    VIN start:
    0E000501-0E161734
    VIN end:
    6E063120-6E072189
    Car Build Date:
    22/08/2002 - 24/04/2006
    Concern:
    Air Bag Control Module For The Supplemental Restraint System Could Be Susceptible To Internal Shorting
    Defect:
    Possible inadvertent air bag deployment.
    Remedy:
    Replace the airbag sensor assembly.
  • Announcement date:
    29/01/2018
    Recalls number:
    R/2017/329
    VIN start:
    SB1BT76L##E016925
    VIN end:
    SB1BT76L##E019991
    Car Build Date:
    22/06/2016 - 25/10/2016
    Concern:
    Bolts On The Exhaust Side Of The Turbocharger Assembly May Be Incorrectly Tightened
    Defect:
    Affected vehicles have a 2.0 litre turbocharged diesel engine. There is a possibility that the bolts on the exhaust-side of the turbocharger assembly may not have been correctly tightened during manufacture.
    Remedy:
    On affected vehicles check bolts. Where necessary replace the turbocharger.
  • Announcement date:
    29/01/2018
    Recalls number:
    R/2017/329
    VIN start:
    SB1ET76L##E016918
    VIN end:
    SB1ET76L##E019999
    Car Build Date:
    22/06/2016 - 26/10/2016
    Concern:
    Bolts On The Exhaust Side Of The Turbocharger Assembly May Be Incorrectly Tightened
    Defect:
    Affected vehicles have a 2.0 litre turbocharged diesel engine. There is a possibility that the bolts on the exhaust-side of the turbocharger assembly may not have been correctly tightened during manufacture.
    Remedy:
    On affected vehicles check bolts. Where necessary replace the turbocharger.
  • Announcement date:
    05/06/2017
    Recalls number:
    R/2017/010
    VIN start:
    SB1EG76L#0E130710
    VIN end:
    SB1EG76L#0E133150
    Car Build Date:
    09/09/2016 - 21/10/2016
    Concern:
    Airbag May Not Deploy
    Defect:
    The subject vehicles are equipped with right front seat side airbags which may not deploy in a collision as intended.
    Remedy:
    Recall the vehicles that are likely to be affected and replace the right front seat side airbags.
  • Announcement date:
    05/06/2017
    Recalls number:
    R/2017/010
    VIN start:
    73910
    VIN end:
    05051
    Car Build Date:
    31/08/2016 - 15/12/2016
    Concern:
    Airbag May Not Deploy
    Defect:
    The subject vehicles are equipped with right front seat side airbags which may not deploy in a collision as intended.
    Remedy:
    Recall the vehicles that are likely to be affected and replace the right front seat side airbags.
  • Announcement date:
    05/06/2017
    Recalls number:
    R/2017/010
    VIN start:
    SB1EN76L#0E013372
    VIN end:
    SB1EN76L#0E019892
    Car Build Date:
    06/09/2016 - 21/10/2016
    Concern:
    Airbag May Not Deploy
    Defect:
    The subject vehicles are equipped with right front seat side airbags which may not deploy in a collision as intended.
    Remedy:
    Recall the vehicles that are likely to be affected and replace the right front seat side airbags.
  • Announcement date:
    05/06/2017
    Recalls number:
    R/2017/010
    VIN start:
    SB1BN76L#0E013378
    VIN end:
    SB1BN76L#0E010697
    Car Build Date:
    06/09/2016 - 21/10/2016
    Concern:
    Airbag May Not Deploy
    Defect:
    The subject vehicles are equipped with right front seat side airbags which may not deploy in a collision as intended.
    Remedy:
    Recall the vehicles that are likely to be affected and replace the right front seat side airbags.
  • Announcement date:
    05/06/2017
    Recalls number:
    R/2017/010
    VIN start:
    SB1BG76L#0E130701
    VIN end:
    SB1BG76L#0E133151
    Car Build Date:
    06/10/2016 - 21/10/2016
    Concern:
    Airbag May Not Deploy
    Defect:
    The subject vehicles are equipped with right front seat side airbags which may not deploy in a collision as intended.
    Remedy:
    Recall the vehicles that are likely to be affected and replace the right front seat side airbags.
  • Announcement date:
    07/01/2016
    Recalls number:
    R/2015/225
    VIN start:
    SB1BG76L##E001012
    VIN end:
    SB1BG76L##E001259
    Car Build Date:
    24/10/2008 - 31/10/2008
    Concern:
    Loss Of Power
    Defect:
    Internal cluctch pistons may have been incorrectly manufacturerd. This may cause incorrect transmission operation.
    Remedy:
    On affected vehicles inspect clutch opertaion. Depending on out come either replace clutch component or transmission unit.
  • Announcement date:
    07/01/2016
    Recalls number:
    R/2015/225
    VIN start:
    SB1EG76L##E001004
    VIN end:
    SB1EG76L##E001217
    Car Build Date:
    24/10/2008 - 31/10/2008
    Concern:
    Loss Of Power
    Defect:
    Internal cluctch pistons may have been incorrectly manufacturerd. This may cause incorrect transmission operation.
    Remedy:
    On affected vehicles inspect clutch opertaion. Depending on out come either replace clutch component or transmission unit.
  • Announcement date:
    08/09/2015
    Recalls number:
    R/2015/166
    VIN start:
    SB1EK76L#0E037002
    VIN end:
    SB1EG76L#0E037463
    Car Build Date:
    19/08/2013 - 21/12/2013
    Concern:
    Roof Window Glass May Detach
    Defect:
    The roof window glass may not have been correctly installed . This may allow the glass to separate from its frame. Initially this will lead to wind noise but continued use could cause the glass to detach from the frame.
    Remedy:
    Replace roof glass.
  • Announcement date:
    08/09/2015
    Recalls number:
    R/2015/166
    VIN start:
    SB1ED76L#0E039578
    VIN end:
    SB1EA76L#0E040212
    Car Build Date:
    19/08/2013 - 21/12/2013
    Concern:
    Roof Window Glass May Detach
    Defect:
    The roof window glass may not have been correctly installed . This may allow the glass to separate from its frame. Initially this will lead to wind noise but continued use could cause the glass to detach from the frame.
    Remedy:
    Replace roof glass.
  • Announcement date:
    08/09/2015
    Recalls number:
    R/2015/166
    VIN start:
    SB1EE76L#0E029602
    VIN end:
    SB1EE76L#0E029652
    Car Build Date:
    19/08/2013 - 21/12/2013
    Concern:
    Roof Window Glass May Detach
    Defect:
    The roof window glass may not have been correctly installed . This may allow the glass to separate from its frame. Initially this will lead to wind noise but continued use could cause the glass to detach from the frame.
    Remedy:
    Replace roof glass.
  • Announcement date:
    08/09/2015
    Recalls number:
    R/2015/166
    VIN start:
    SBTED76L#0E120936
    VIN end:
    SB1ED76L#0E124965
    Car Build Date:
    19/08/2013 - 21/12/2013
    Concern:
    Roof Window Glass May Detach
    Defect:
    The roof window glass may not have been correctly installed . This may allow the glass to separate from its frame. Initially this will lead to wind noise but continued use could cause the glass to detach from the frame.
    Remedy:
    Replace roof glass.
  • Announcement date:
    08/09/2015
    Recalls number:
    R/2015/166
    VIN start:
    SB1EB76L#0E039561
    VIN end:
    SB1EB76L#0E040244
    Car Build Date:
    19/08/2013 - 21/12/2013
    Concern:
    Roof Window Glass May Detach
    Defect:
    The roof window glass may not have been correctly installed . This may allow the glass to separate from its frame. Initially this will lead to wind noise but continued use could cause the glass to detach from the frame.
    Remedy:
    Replace roof glass.
  • Announcement date:
    08/09/2015
    Recalls number:
    R/2015/166
    VIN start:
    SB1EG76L#0E092401
    VIN end:
    SB1EG76L#0E093207
    Car Build Date:
    19/08/2013 - 21/12/2013
    Concern:
    Roof Window Glass May Detach
    Defect:
    The roof window glass may not have been correctly installed . This may allow the glass to separate from its frame. Initially this will lead to wind noise but continued use could cause the glass to detach from the frame.
    Remedy:
    Replace roof glass.
  • Announcement date:
    15/06/2015
    Recalls number:
    R/2015/096
    VIN start:
    SB1BF5####E001003
    VIN end:
    SB1ER5####E226841
    Car Build Date:
    29/01/2003 - 22/12/2007
    Concern:
    Passenger Side Airbag May Fail To Deploy Correctly
    Defect:
    The subject vehicles are equipped with front passenger airbag inflators which could have been assembled with improperly manufactured propellant wafers. Improperly manufactured propellant wafers could cause the inflator to rupture and the front passenger airbag to deploy abnormally in a crash. This could result in increased risk of injury to the occupant and the possibility of a fire.
    Remedy:
    Recall the vehicles that are likely to be affected to replace the airbag.
  • Announcement date:
    17/04/2013
    Recalls number:
    R/2013/048
    Car Build Date:
    08/01/2001 - 15/11/2003
    Concern:
    Passenger Side Airbag May Fail To Deploy Correctly
    Defect:
    The subject vehicles are equipped with front passenger airbag inflators which could have been assembled with improperly manufactured propellant wafers. Improperly manufactured propellant wafers could cause the inflator to rupture and the front passenger airbag to deploy abnormally in a crash. This could result in increased risk of injury to the occupant and the possibility of a fire.
    Remedy:
    Recall the vehicles that are likely to be affected to replace the airbag.
  • Announcement date:
    03/12/2012
    Recalls number:
    R/2012/145
    VIN start:
    SB1BZ56L##E000519
    VIN end:
    SB1BZ56L##E072742
    Car Build Date:
    21/08/2002 - 14/10/2008
    Concern:
    Loss Of Steering
    Defect:
    It is possible that the splines of the extension shaft on vehicles equipped with Electric Motor assisted Power Steering (EMPS) may not have received the correct hardness treatment. This can cause the spline to distort and wear and eventually result in loss of steering.
    Remedy:
    Recall affected vehicles check and if necessary replace the shaft.
  • Announcement date:
    03/12/2012
    Recalls number:
    R/2012/145
    VIN start:
    SB1BZ55L##E000516
    VIN end:
    SB1BZ55L##E066406
    Car Build Date:
    21/08/2002 - 14/10/2008
    Concern:
    Loss Of Steering
    Defect:
    It is possible that the splines of the extension shaft on vehicles equipped with Electric Motor assisted Power Steering (EMPS) may not have received the correct hardness treatment. This can cause the spline to distort and wear and eventually result in loss of steering.
    Remedy:
    Recall affected vehicles check and if necessary replace the shaft.
  • Announcement date:
    03/12/2012
    Recalls number:
    R/2012/145
    VIN start:
    SB1DZ55L##E000531
    VIN end:
    SB1DZ55L##E049032
    Car Build Date:
    21/08/2002 - 14/10/2008
    Concern:
    Loss Of Steering
    Defect:
    It is possible that the splines of the extension shaft on vehicles equipped with Electric Motor assisted Power Steering (EMPS) may not have received the correct hardness treatment. This can cause the spline to distort and wear and eventually result in loss of steering.
    Remedy:
    Recall affected vehicles check and if necessary replace the shaft.
  • Announcement date:
    03/12/2012
    Recalls number:
    R/2012/145
    VIN start:
    SB1DZ56L##E000547
    VIN end:
    SB1DZ56L##E071872
    Car Build Date:
    21/08/2002 - 14/10/2008
    Concern:
    Loss Of Steering
    Defect:
    It is possible that the splines of the extension shaft on vehicles equipped with Electric Motor assisted Power Steering (EMPS) may not have received the correct hardness treatment. This can cause the spline to distort and wear and eventually result in loss of steering.
    Remedy:
    Recall affected vehicles check and if necessary replace the shaft.
  • Announcement date:
    03/12/2012
    Recalls number:
    R/2012/145
    VIN start:
    SB1EZ55L##E000611
    VIN end:
    SB1EZ55L##E049901
    Car Build Date:
    21/08/2002 - 14/10/2008
    Concern:
    Loss Of Steering
    Defect:
    It is possible that the splines of the extension shaft on vehicles equipped with Electric Motor assisted Power Steering (EMPS) may not have received the correct hardness treatment. This can cause the spline to distort and wear and eventually result in loss of steering.
    Remedy:
    Recall affected vehicles check and if necessary replace the shaft.
  • Announcement date:
    03/12/2012
    Recalls number:
    R/2012/145
    VIN start:
    SB1BR55L##E000552
    VIN end:
    SB1BR55L##E161715
    Car Build Date:
    21/08/2002 - 14/10/2008
    Concern:
    Loss Of Steering
    Defect:
    It is possible that the splines of the extension shaft on vehicles equipped with Electric Motor assisted Power Steering (EMPS) may not have received the correct hardness treatment. This can cause the spline to distort and wear and eventually result in loss of steering.
    Remedy:
    Recall affected vehicles check and if necessary replace the shaft.
  • Announcement date:
    03/12/2012
    Recalls number:
    R/2012/145
    VIN start:
    SB1BR56L##E000501
    VIN end:
    SB1BR56L##E260641
    Car Build Date:
    21/08/2002 - 14/10/2008
    Concern:
    Loss Of Steering
    Defect:
    It is possible that the splines of the extension shaft on vehicles equipped with Electric Motor assisted Power Steering (EMPS) may not have received the correct hardness treatment. This can cause the spline to distort and wear and eventually result in loss of steering.
    Remedy:
    Recall affected vehicles check and if necessary replace the shaft.
  • Announcement date:
    03/12/2012
    Recalls number:
    R/2012/145
    VIN start:
    SB1DR56L##E000505
    VIN end:
    SB1DR56L##E260572
    Car Build Date:
    21/08/2002 - 14/10/2008
    Concern:
    Loss Of Steering
    Defect:
    It is possible that the splines of the extension shaft on vehicles equipped with Electric Motor assisted Power Steering (EMPS) may not have received the correct hardness treatment. This can cause the spline to distort and wear and eventually result in loss of steering.
    Remedy:
    Recall affected vehicles check and if necessary replace the shaft.
  • Announcement date:
    03/12/2012
    Recalls number:
    R/2012/145
    VIN start:
    SB1ER56L##E000546
    VIN end:
    SB1ER56L##E260633
    Car Build Date:
    21/08/2002 - 14/10/2008
    Concern:
    Loss Of Steering
    Defect:
    It is possible that the splines of the extension shaft on vehicles equipped with Electric Motor assisted Power Steering (EMPS) may not have received the correct hardness treatment. This can cause the spline to distort and wear and eventually result in loss of steering.
    Remedy:
    Recall affected vehicles check and if necessary replace the shaft.
  • Announcement date:
    03/12/2012
    Recalls number:
    R/2012/145
    VIN start:
    SB1ER55L##E000533
    VIN end:
    SB1ER55L##E155315
    Car Build Date:
    21/08/2002 - 14/10/2008
    Concern:
    Loss Of Steering
    Defect:
    It is possible that the splines of the extension shaft on vehicles equipped with Electric Motor assisted Power Steering (EMPS) may not have received the correct hardness treatment. This can cause the spline to distort and wear and eventually result in loss of steering.
    Remedy:
    Recall affected vehicles check and if necessary replace the shaft.
  • Announcement date:
    03/12/2012
    Recalls number:
    R/2012/145
    VIN start:
    SB1DR55L##E000529
    VIN end:
    SB1DR55L##E159159
    Car Build Date:
    21/08/2002 - 14/10/2008
    Concern:
    Loss Of Steering
    Defect:
    It is possible that the splines of the extension shaft on vehicles equipped with Electric Motor assisted Power Steering (EMPS) may not have received the correct hardness treatment. This can cause the spline to distort and wear and eventually result in loss of steering.
    Remedy:
    Recall affected vehicles check and if necessary replace the shaft.
  • Announcement date:
    26/10/2012
    Recalls number:
    R/2012/102
    VIN start:
    SB1E#5#L#OE001007
    VIN end:
    SB1E#5#L#OE260633
    Car Build Date:
    22/01/2003 - 14/10/2008
    Concern:
    Tow Ball May Fracture
    Defect:
    On Toyota Avensis Previa and Lexus GS fitted with a Toyota or Lexus genuine or Brink branded (only on Avensis) detachable towing hitch the possibility exists that the detachable towing ball in some exceptional cases (under severe mechanical stress) might develop a crack. In a worst case the detachable towing ball might fracture and/or fail.
    Remedy:
    Lexus/Toyota dealers will replace the detachable towing ball and housing at no cost to vehicle owners.
  • Announcement date:
    26/10/2012
    Recalls number:
    R/2012/102
    VIN start:
    SB1D#5#L#OE001005
    VIN end:
    SB1D#5#L#OE101337
    Car Build Date:
    18/04/2005 - 13/10/2008
    Concern:
    Tow Ball May Fracture
    Defect:
    On Toyota Avensis Previa and Lexus GS fitted with a Toyota or Lexus genuine or Brink branded (only on Avensis) detachable towing hitch the possibility exists that the detachable towing ball in some exceptional cases (under severe mechanical stress) might develop a crack. In a worst case the detachable towing ball might fracture and/or fail.
    Remedy:
    Lexus/Toyota dealers will replace the detachable towing ball and housing at no cost to vehicle owners.
  • Announcement date:
    26/10/2012
    Recalls number:
    R/2012/102
    VIN start:
    SB1B#5#L#OE001001
    VIN end:
    SB1E#5#L#OE101338
    Car Build Date:
    18/04/2005 - 13/10/2008
    Concern:
    Tow Ball May Fracture
    Defect:
    On Toyota Avensis Previa and Lexus GS fitted with a Toyota or Lexus genuine or Brink branded (only on Avensis) detachable towing hitch the possibility exists that the detachable towing ball in some exceptional cases (under severe mechanical stress) might develop a crack. In a worst case the detachable towing ball might fracture and/or fail.
    Remedy:
    Lexus/Toyota dealers will replace the detachable towing ball and housing at no cost to vehicle owners.
  • Announcement date:
    26/10/2012
    Recalls number:
    R/2012/102
    VIN start:
    SB1B#5#L#OE001001
    VIN end:
    SB1B#5#L#OE101299
    Car Build Date:
    18/04/2005 - 13/10/2008
    Concern:
    Tow Ball May Fracture
    Defect:
    On Toyota Avensis Previa and Lexus GS fitted with a Toyota or Lexus genuine or Brink branded (only on Avensis) detachable towing hitch the possibility exists that the detachable towing ball in some exceptional cases (under severe mechanical stress) might develop a crack. In a worst case the detachable towing ball might fracture and/or fail.
    Remedy:
    Lexus/Toyota dealers will replace the detachable towing ball and housing at no cost to vehicle owners.
  • Announcement date:
    26/10/2012
    Recalls number:
    R/2012/102
    VIN start:
    SB1D#5#L#OE001008
    VIN end:
    SB1D#5#L#OE118230
    Car Build Date:
    28/01/2003 - 13/10/2008
    Concern:
    Tow Ball May Fracture
    Defect:
    On Toyota Avensis Previa and Lexus GS fitted with a Toyota or Lexus genuine or Brink branded (only on Avensis) detachable towing hitch the possibility exists that the detachable towing ball in some exceptional cases (under severe mechanical stress) might develop a crack. In a worst case the detachable towing ball might fracture and/or fail.
    Remedy:
    Lexus/Toyota dealers will replace the detachable towing ball and housing at no cost to vehicle owners.
  • Announcement date:
    26/10/2012
    Recalls number:
    R/2012/102
    VIN start:
    SB1E#5#L#OE001001
    VIN end:
    SB1E#5#L#OE118309
    Car Build Date:
    28/01/2003 - 13/10/2008
    Concern:
    Tow Ball May Fracture
    Defect:
    On Toyota Avensis Previa and Lexus GS fitted with a Toyota or Lexus genuine or Brink branded (only on Avensis) detachable towing hitch the possibility exists that the detachable towing ball in some exceptional cases (under severe mechanical stress) might develop a crack. In a worst case the detachable towing ball might fracture and/or fail.
    Remedy:
    Lexus/Toyota dealers will replace the detachable towing ball and housing at no cost to vehicle owners.
  • Announcement date:
    26/10/2012
    Recalls number:
    R/2012/102
    VIN start:
    SB1E#5#L#OE001015
    VIN end:
    SB1E#5#L#OE148954
    Car Build Date:
    12/03/2003 - 10/04/2006
    Concern:
    Tow Ball May Fracture
    Defect:
    On Toyota Avensis Previa and Lexus GS fitted with a Toyota or Lexus genuine or Brink branded (only on Avensis) detachable towing hitch the possibility exists that the detachable towing ball in some exceptional cases (under severe mechanical stress) might develop a crack. In a worst case the detachable towing ball might fracture and/or fail.
    Remedy:
    Lexus/Toyota dealers will replace the detachable towing ball and housing at no cost to vehicle owners.
  • Announcement date:
    26/10/2012
    Recalls number:
    R/2012/102
    VIN start:
    SB1D#5#L#OE001013
    VIN end:
    SB1D#5#L#OE148952
    Car Build Date:
    12/03/2003 - 10/04/2006
    Concern:
    Tow Ball May Fracture
    Defect:
    On Toyota Avensis Previa and Lexus GS fitted with a Toyota or Lexus genuine or Brink branded (only on Avensis) detachable towing hitch the possibility exists that the detachable towing ball in some exceptional cases (under severe mechanical stress) might develop a crack. In a worst case the detachable towing ball might fracture and/or fail.
    Remedy:
    Lexus/Toyota dealers will replace the detachable towing ball and housing at no cost to vehicle owners.
  • Announcement date:
    26/10/2012
    Recalls number:
    R/2012/102
    VIN start:
    SB1D#5#L#OE001002
    VIN end:
    SB1D#5#L#OE260641
    Car Build Date:
    22/01/2003 - 14/10/2008
    Concern:
    Tow Ball May Fracture
    Defect:
    On Toyota Avensis Previa and Lexus GS fitted with a Toyota or Lexus genuine or Brink branded (only on Avensis) detachable towing hitch the possibility exists that the detachable towing ball in some exceptional cases (under severe mechanical stress) might develop a crack. In a worst case the detachable towing ball might fracture and/or fail.
    Remedy:
    Lexus/Toyota dealers will replace the detachable towing ball and housing at no cost to vehicle owners.
  • Announcement date:
    26/10/2012
    Recalls number:
    R/2012/102
    VIN start:
    SB1B#5#L#OE001005
    VIN end:
    SB1B#5#L#OE260641
    Car Build Date:
    22/01/2003 - 14/10/2008
    Concern:
    Tow Ball May Fracture
    Defect:
    On Toyota Avensis Previa and Lexus GS fitted with a Toyota or Lexus genuine or Brink branded (only on Avensis) detachable towing hitch the possibility exists that the detachable towing ball in some exceptional cases (under severe mechanical stress) might develop a crack. In a worst case the detachable towing ball might fracture and/or fail.
    Remedy:
    Lexus/Toyota dealers will replace the detachable towing ball and housing at no cost to vehicle owners.
  • Announcement date:
    26/10/2012
    Recalls number:
    R/2012/102
    VIN start:
    SB1B#5#L#OE001014
    VIN end:
    SB1B#5#L#OE148925
    Car Build Date:
    12/03/2003 - 10/04/2006
    Concern:
    Tow Ball May Fracture
    Defect:
    On Toyota Avensis Previa and Lexus GS fitted with a Toyota or Lexus genuine or Brink branded (only on Avensis) detachable towing hitch the possibility exists that the detachable towing ball in some exceptional cases (under severe mechanical stress) might develop a crack. In a worst case the detachable towing ball might fracture and/or fail.
    Remedy:
    Lexus/Toyota dealers will replace the detachable towing ball and housing at no cost to vehicle owners.
  • Announcement date:
    26/10/2012
    Recalls number:
    R/2012/102
    VIN start:
    SB1B#5#L##E001004
    VIN end:
    SB1B#5#L##E117306
    Car Build Date:
    28/01/2003 - 13/10/2008
    Concern:
    Tow Ball May Fracture
    Defect:
    On Toyota Avensis Previa and Lexus GS fitted with a Toyota or Lexus genuine or Brink branded (only on Avensis) detachable towing hitch the possibility exists that the detachable towing ball in some exceptional cases (under severe mechanical stress) might develop a crack. In a worst case the detachable towing ball might fracture and/or fail.
    Remedy:
    Lexus/Toyota dealers will replace the detachable towing ball and housing at no cost to vehicle owners.
  • Announcement date:
    26/10/2012
    Recalls number:
    R/2012/102
    VIN start:
    SB1D#5#L#OE001002
    VIN end:
    SB1D#5#L#OE260572
    Car Build Date:
    22/01/2003 - 14/10/2008
    Concern:
    Tow Ball May Fracture
    Defect:
    On Toyota Avensis Previa and Lexus GS fitted with a Toyota or Lexus genuine or Brink branded (only on Avensis) detachable towing hitch the possibility exists that the detachable towing ball in some exceptional cases (under severe mechanical stress) might develop a crack. In a worst case the detachable towing ball might fracture and/or fail.
    Remedy:
    Lexus/Toyota dealers will replace the detachable towing ball and housing at no cost to vehicle owners.
  • Announcement date:
    12/09/2012
    Recalls number:
    R/2012/085
    VIN start:
    SB1#K7#L##E001001
    VIN end:
    SB1#K7#L##E021994
    Car Build Date:
    22/10/2008 - 18/01/2011
    Concern:
    Rear Suspension Arm May Separate
    Defect:
    If the rear suspension arm is adjusted as part of a wheel alignment or other repairs whilst in service it is possible that backlash can occur. This can allow corrosion to develop and cause the threads to deteriorate. Ultimately this could result in failure of the arm with a resultant loss of control of the vehicle.
    Remedy:
    Recall all affected vehicles to check the torque on the arm. Where necessary the arm will be replaced.
  • Announcement date:
    12/09/2012
    Recalls number:
    R/2012/085
    VIN start:
    SB1#B7#L##E001003
    VIN end:
    SB1#B7#L##E026534
    Car Build Date:
    22/10/2008 - 18/01/2011
    Concern:
    Rear Suspension Arm May Separate
    Defect:
    If the rear suspension arm is adjusted as part of a wheel alignment or other repairs whilst in service it is possible that backlash can occur. This can allow corrosion to develop and cause the threads to deteriorate. Ultimately this could result in failure of the arm with a resultant loss of control of the vehicle.
    Remedy:
    Recall all affected vehicles to check the torque on the arm. Where necessary the arm will be replaced.
  • Announcement date:
    12/09/2012
    Recalls number:
    R/2012/085
    VIN start:
    SB1#E7#L##E001001
    VIN end:
    SB1#E7#L##E017694
    Car Build Date:
    22/10/2008 - 18/01/2011
    Concern:
    Rear Suspension Arm May Separate
    Defect:
    If the rear suspension arm is adjusted as part of a wheel alignment or other repairs whilst in service it is possible that backlash can occur. This can allow corrosion to develop and cause the threads to deteriorate. Ultimately this could result in failure of the arm with a resultant loss of control of the vehicle.
    Remedy:
    Recall all affected vehicles to check the torque on the arm. Where necessary the arm will be replaced.
  • Announcement date:
    12/09/2012
    Recalls number:
    R/2012/085
    VIN start:
    SB1#G7#L##E001001
    VIN end:
    SB1#67#L##E048290
    Car Build Date:
    22/10/2008 - 18/01/2011
    Concern:
    Rear Suspension Arm May Separate
    Defect:
    If the rear suspension arm is adjusted as part of a wheel alignment or other repairs whilst in service it is possible that backlash can occur. This can allow corrosion to develop and cause the threads to deteriorate. Ultimately this could result in failure of the arm with a resultant loss of control of the vehicle.
    Remedy:
    Recall all affected vehicles to check the torque on the arm. Where necessary the arm will be replaced.
  • Announcement date:
    12/09/2012
    Recalls number:
    R/2012/085
    VIN start:
    SB1#A7#L##E001001
    VIN end:
    SB1#A7#L##E026535
    Car Build Date:
    22/10/2008 - 18/01/2011
    Concern:
    Rear Suspension Arm May Separate
    Defect:
    If the rear suspension arm is adjusted as part of a wheel alignment or other repairs whilst in service it is possible that backlash can occur. This can allow corrosion to develop and cause the threads to deteriorate. Ultimately this could result in failure of the arm with a resultant loss of control of the vehicle.
    Remedy:
    Recall all affected vehicles to check the torque on the arm. Where necessary the arm will be replaced.
  • Announcement date:
    12/09/2012
    Recalls number:
    R/2012/085
    VIN start:
    SB1#D7#L##E001001
    VIN end:
    SB1#D7#L##E058246
    Car Build Date:
    22/10/2008 - 18/01/2011
    Concern:
    Rear Suspension Arm May Separate
    Defect:
    If the rear suspension arm is adjusted as part of a wheel alignment or other repairs whilst in service it is possible that backlash can occur. This can allow corrosion to develop and cause the threads to deteriorate. Ultimately this could result in failure of the arm with a resultant loss of control of the vehicle.
    Remedy:
    Recall all affected vehicles to check the torque on the arm. Where necessary the arm will be replaced.
  • Announcement date:
    17/02/2011
    Recalls number:
    R/2011/005
    VIN start:
    SB1#J56L##E000504
    VIN end:
    SB1#J56L##E012025
    Car Build Date:
    23/08/2002 - 09/09/2003
    Concern:
    Fuel May Leak
    Defect:
    It is possible that during the manufacturing process the wall thickness of the high pressure supply pipe may have been reduced. If the driving conditions of the vehicle cause fuel pressure fluctuations this could cause cracking and result in a fuel leak. Also due to gasket fatigue and prolonged usage the high pressure fuel pump check valve may be come loose and leak.
    Remedy:
    Recall all affected vehicles for the replacement of the fuel pipe and fuel pump check valve plus gasket.
  • Announcement date:
    17/02/2011
    Recalls number:
    R/2011/005
    VIN start:
    SB1#P56L##E001018
    VIN end:
    SB1#P56L##E015584
    Car Build Date:
    19/09/2003 - 18/06/2008
    Concern:
    Fuel May Leak
    Defect:
    It is possible that during the manufacturing process the wall thickness of the high pressure supply pipe may have been reduced. If the driving conditions of the vehicle cause fuel pressure fluctuations this could cause cracking and result in a fuel leak. Also due to gasket fatigue and prolonged usage the high pressure fuel pump check valve may be come loose and leak.
    Remedy:
    Recall all affected vehicles for the replacement of the fuel pipe and fuel pump check valve plus gasket.
  • Announcement date:
    17/02/2011
    Recalls number:
    R/2011/005
    VIN start:
    SB1#P56L##E001008
    VIN end:
    SB1#P56L##E001013
    Car Build Date:
    09/06/2003 - 16/06/2003
    Concern:
    Fuel May Leak
    Defect:
    It is possible that during the manufacturing process the wall thickness of the high pressure supply pipe may have been reduced. If the driving conditions of the vehicle cause fuel pressure fluctuations this could cause cracking and result in a fuel leak. Also due to gasket fatigue and prolonged usage the high pressure fuel pump check valve may be come loose and leak.
    Remedy:
    Recall all affected vehicles for the replacement of the fuel pipe and fuel pump check valve plus gasket.
  • Announcement date:
    17/02/2011
    Recalls number:
    R/2011/005
    VIN start:
    SB1#J56L##E012026
    VIN end:
    SB1#J56L##E117506
    Car Build Date:
    09/07/2003 - 09/07/2008
    Concern:
    Fuel May Leak
    Defect:
    It is possible that during the manufacturing process the wall thickness of the high pressure supply pipe may have been reduced. If the driving conditions of the vehicle cause fuel pressure fluctuations this could cause cracking and result in a fuel leak. Also due to gasket fatigue and prolonged usage the high pressure fuel pump check valve may be come loose and leak.
    Remedy:
    Recall all affected vehicles for the replacement of the fuel pipe and fuel pump check valve plus gasket.
  • Announcement date:
    17/02/2011
    Recalls number:
    R/2011/005
    VIN start:
    SB1#J55L##E063120
    VIN end:
    SB1#J55L##E114755
    Car Build Date:
    26/08/2005 - 02/05/2008
    Concern:
    Fuel May Leak
    Defect:
    It is possible that during the manufacturing process the wall thickness of the high pressure supply pipe may have been reduced. If the driving conditions of the vehicle cause fuel pressure fluctuations this could cause cracking and result in a fuel leak. Also due to gasket fatigue and prolonged usage the high pressure fuel pump check valve may be come loose and leak.
    Remedy:
    Recall all affected vehicles for the replacement of the fuel pipe and fuel pump check valve plus gasket.
  • Announcement date:
    17/02/2011
    Recalls number:
    R/2011/005
    VIN start:
    SB1##BBN##E000020
    VIN end:
    SB1##BBN##E023672
    Car Build Date:
    10/07/2000 - 22/12/2002
    Concern:
    Fuel May Leak
    Defect:
    It is possible that during the manufacturing process the wall thickness of the high pressure supply pipe may have been reduced. If the driving conditions of the vehicle cause fuel pressure fluctuations this could cause cracking and result in a fuel leak. Also due to gasket fatigue and prolonged usage the high pressure fuel pump check valve may be come loose and leak.
    Remedy:
    Recall all affected vehicles for the replacement of the fuel pipe and fuel pump check valve plus gasket.
  • Announcement date:
    06/02/2010
    Recalls number:
    R/2010/010
    Car Build Date:
    01/11/2008 - 31/12/2009
    Concern:
    Accelerator Pedal May Fail To Return To Idle
    Defect:
    It has been identified that on affected vehicles condensation resulting from cold-weather use of the heater or other causes may form on the worn surface of a component within the throttle pedal assembly known as the friction device. If this occurs there is a possibility that in the worst case the accelerator pedal may return slowly or does not return to the engine idle position.
    Remedy:
    Recalled vehicles will have a precision-cut steel reinforcing bar fitted into the accelerator pedal assembly which will create a space in order to reduce the surface tension between the friction device and a component referred to as the pedal arm. The subject bar also strengthens the reaction force of the spring that returns the accelerator pedal to it's non-pressed position.
  • Announcement date:
    18/11/2009
    Recalls number:
    R/2009/084
    VIN start:
    SB1EE76L6OE001288
    VIN end:
    SB1EE76L6OE001288
    Car Build Date:
    28/10/2008 - 10/02/2009
    Concern:
    Towing Hitch May Detach
    Defect:
    It has been identified that on certain vehicles equipped with a genuine Toyota towing hitch the hitch installation bolts were over-tightened. In the worst case the bolts may break under certain conditions of usage.
    Remedy:
    Recalled vehicles will have the hitch installation bolts replaced and tightened to the correct torque.
  • Announcement date:
    18/11/2009
    Recalls number:
    R/2009/084
    VIN start:
    SB1ED76L#OE001087
    VIN end:
    SB1ED76L#OE010770
    Car Build Date:
    29/10/2008 - 10/02/2009
    Concern:
    Towing Hitch May Detach
    Defect:
    It has been identified that on certain vehicles equipped with a genuine Toyota towing hitch the hitch installation bolts were over-tightened. In the worst case the bolts may break under certain conditions of usage.
    Remedy:
    Recalled vehicles will have the hitch installation bolts replaced and tightened to the correct torque.
  • Announcement date:
    18/11/2009
    Recalls number:
    R/2009/084
    VIN start:
    SB1BE76L#OE001388
    VIN end:
    SB1BE76L#OE002436
    Car Build Date:
    29/10/2008 - 10/02/2009
    Concern:
    Towing Hitch May Detach
    Defect:
    It has been identified that on certain vehicles equipped with a genuine Toyota towing hitch the hitch installation bolts were over-tightened. In the worst case the bolts may break under certain conditions of usage.
    Remedy:
    Recalled vehicles will have the hitch installation bolts replaced and tightened to the correct torque.
  • Announcement date:
    18/11/2009
    Recalls number:
    R/2009/084
    VIN start:
    SB1BK76L#OE001182
    VIN end:
    SB1BK76L#OE003235
    Car Build Date:
    29/10/2008 - 10/02/2009
    Concern:
    Towing Hitch May Detach
    Defect:
    It has been identified that on certain vehicles equipped with a genuine Toyota towing hitch the hitch installation bolts were over-tightened. In the worst case the bolts may break under certain conditions of usage.
    Remedy:
    Recalled vehicles will have the hitch installation bolts replaced and tightened to the correct torque.
  • Announcement date:
    18/11/2009
    Recalls number:
    R/2009/084
    VIN start:
    SB1BG76L#OE002086
    VIN end:
    SB1BG76L#OE007773
    Car Build Date:
    29/10/2008 - 10/02/2009
    Concern:
    Towing Hitch May Detach
    Defect:
    It has been identified that on certain vehicles equipped with a genuine Toyota towing hitch the hitch installation bolts were over-tightened. In the worst case the bolts may break under certain conditions of usage.
    Remedy:
    Recalled vehicles will have the hitch installation bolts replaced and tightened to the correct torque.
  • Announcement date:
    18/11/2009
    Recalls number:
    R/2009/084
    VIN start:
    SB1EA76L#0E001308
    VIN end:
    SB1EA76L#0E004932
    Car Build Date:
    29/10/2008 - 10/02/2009
    Concern:
    Towing Hitch May Detach
    Defect:
    It has been identified that on certain vehicles equipped with a genuine Toyota towing hitch the hitch installation bolts were over-tightened. In the worst case the bolts may break under certain conditions of usage.
    Remedy:
    Recalled vehicles will have the hitch installation bolts replaced and tightened to the correct torque.
  • Announcement date:
    18/11/2009
    Recalls number:
    R/2009/084
    VIN start:
    SBIBB76L#0E002051
    VIN end:
    SB1BB76L#0E005356
    Car Build Date:
    29/10/2008 - 10/02/2009
    Concern:
    Towing Hitch May Detach
    Defect:
    It has been identified that on certain vehicles equipped with a genuine Toyota towing hitch the hitch installation bolts were over-tightened. In the worst case the bolts may break under certain conditions of usage.
    Remedy:
    Recalled vehicles will have the hitch installation bolts replaced and tightened to the correct torque.
  • Announcement date:
    18/11/2009
    Recalls number:
    R/2009/084
    VIN start:
    SB1EB76L#0E001045
    VIN end:
    SB1EB76L#0E006037
    Car Build Date:
    29/10/2008 - 10/02/2009
    Concern:
    Towing Hitch May Detach
    Defect:
    It has been identified that on certain vehicles equipped with a genuine Toyota towing hitch the hitch installation bolts were over-tightened. In the worst case the bolts may break under certain conditions of usage.
    Remedy:
    Recalled vehicles will have the hitch installation bolts replaced and tightened to the correct torque.
  • Announcement date:
    18/11/2009
    Recalls number:
    R/2009/084
    VIN start:
    SB1EK76L#OE001065
    VIN end:
    SB1EK76L#OE004592
    Car Build Date:
    29/10/2008 - 10/02/2009
    Concern:
    Towing Hitch May Detach
    Defect:
    It has been identified that on certain vehicles equipped with a genuine Toyota towing hitch the hitch installation bolts were over-tightened. In the worst case the bolts may break under certain conditions of usage.
    Remedy:
    Recalled vehicles will have the hitch installation bolts replaced and tightened to the correct torque.
  • Announcement date:
    18/11/2009
    Recalls number:
    R/2009/084
    VIN start:
    SB1BD76L#OE001525
    VIN end:
    SB1BD76L#OE007247
    Car Build Date:
    29/10/2008 - 10/02/2009
    Concern:
    Towing Hitch May Detach
    Defect:
    It has been identified that on certain vehicles equipped with a genuine Toyota towing hitch the hitch installation bolts were over-tightened. In the worst case the bolts may break under certain conditions of usage.
    Remedy:
    Recalled vehicles will have the hitch installation bolts replaced and tightened to the correct torque.
  • Announcement date:
    18/11/2009
    Recalls number:
    R/2009/084
    VIN start:
    SB1EG76L#OE001073
    VIN end:
    SB1EG76L#OE007313
    Car Build Date:
    29/10/2008 - 10/02/2009
    Concern:
    Towing Hitch May Detach
    Defect:
    It has been identified that on certain vehicles equipped with a genuine Toyota towing hitch the hitch installation bolts were over-tightened. In the worst case the bolts may break under certain conditions of usage.
    Remedy:
    Recalled vehicles will have the hitch installation bolts replaced and tightened to the correct torque.
  • Announcement date:
    21/11/2006
    Recalls number:
    R/2006/165
    VIN start:
    SB1DR56L#0E163333
    VIN end:
    SB1DR56L#0E167862
    Car Build Date:
    08/05/2006 - 19/06/2006
    Concern:
    Possibility Of Tyre Deflation
    Defect:
    On certain Avensis vehicles equipped with 16 inch steel wheels due to the shape of the wheel trim there is a possibility that the edge of the wheel trim may interfere with the sidewall of the tyre. Should this occur whilst the vehicle is being driven the wheel trims may rotate which could lead to interference with the tyre valve. In the worst case and if the vehicle is continuously driven in this condition loss of tyre pressure could ensue.
    Remedy:
    Recalled vehicles will have the steel wheels (standard equipment) replaced with aluminium alloy wheels.
  • Announcement date:
    21/11/2006
    Recalls number:
    R/2006/165
    VIN start:
    SB1DD56L#0E002416
    VIN end:
    SB1DD56L#0E003153
    Car Build Date:
    08/05/2006 - 19/06/2006
    Concern:
    Possibility Of Tyre Deflation
    Defect:
    On certain Avensis vehicles equipped with 16 inch steel wheels due to the shape of the wheel trim there is a possibility that the edge of the wheel trim may interfere with the sidewall of the tyre. Should this occur whilst the vehicle is being driven the wheel trims may rotate which could lead to interference with the tyre valve. In the worst case and if the vehicle is continuously driven in this condition loss of tyre pressure could ensue.
    Remedy:
    Recalled vehicles will have the steel wheels (standard equipment) replaced with aluminium alloy wheels.
  • Announcement date:
    21/11/2006
    Recalls number:
    R/2006/165
    VIN start:
    SB1ED56L#0E001899
    VIN end:
    SB1ED56L#0E002404
    Car Build Date:
    08/05/2006 - 19/06/2006
    Concern:
    Possibility Of Tyre Deflation
    Defect:
    On certain Avensis vehicles equipped with 16 inch steel wheels due to the shape of the wheel trim there is a possibility that the edge of the wheel trim may interfere with the sidewall of the tyre. Should this occur whilst the vehicle is being driven the wheel trims may rotate which could lead to interference with the tyre valve. In the worst case and if the vehicle is continuously driven in this condition loss of tyre pressure could ensue.
    Remedy:
    Recalled vehicles will have the steel wheels (standard equipment) replaced with aluminium alloy wheels.
  • Announcement date:
    21/11/2006
    Recalls number:
    R/2006/165
    VIN start:
    SB1BR56L#0E163480
    VIN end:
    SB1BR56L#0E166020
    Car Build Date:
    08/05/2006 - 19/06/2006
    Concern:
    Possibility Of Tyre Deflation
    Defect:
    On certain Avensis vehicles equipped with 16 inch steel wheels due to the shape of the wheel trim there is a possibility that the edge of the wheel trim may interfere with the sidewall of the tyre. Should this occur whilst the vehicle is being driven the wheel trims may rotate which could lead to interference with the tyre valve. In the worst case and if the vehicle is continuously driven in this condition loss of tyre pressure could ensue.
    Remedy:
    Recalled vehicles will have the steel wheels (standard equipment) replaced with aluminium alloy wheels.
  • Announcement date:
    13/09/2006
    Recalls number:
    R/2006/103
    VIN start:
    SB1#R5#L#0E001005
    VIN end:
    SB1#R5#L#0E145507
    Car Build Date:
    01/01/2003 - 31/12/2005
    Concern:
    Steering May Fail
    Defect:
    It is possible that the connections at the intermediate shaft and sliding yoke of the steering column may become loose and if the symptoms are ignored steering control can be lost.
    Remedy:
    Recall the vehicles that are likely to be affected and replace the steering intermediate shaft. In addition inspect the sliding yoke and intermediate shaft extension and replace if necessary. This recall is staggered starting with Prius and Corrolla. Avensis customer letters will be sent out over the next three months
  • Announcement date:
    06/12/2004
    Recalls number:
    R/2004/192
    Car Build Date:
    16/08/2004 - 03/09/2004
    Concern:
    Possibility That Suspension Arm Bracket Bolts May Loosen
    Defect:
    Anti-chipping paint (foam filled vinyl chloride) was applied in error to the clamping area where the rear lower suspension arm brackets are connected. This could lead to the bolts loosening over time.
    Remedy:
    Recall the potentially affected vehicles. Check and if necessary remove the incorrectly applied paint then re torque the bolts.
  • Announcement date:
    11/10/2004
    Recalls number:
    R/2004/163
    Car Build Date:
    25/06/2004 - 07/07/2004
    Concern:
    Vsc Warning Light May Illuminate And The System Stop Working
    Defect:
    In rare cases the VSC (vehicle Stability Control) warning light may illuminate and the system stop working due to the Yaw rate sensor becoming disconnected internally. In even rarer cases the VSC may not function correctly even if the VSC light is not illuminated (partial disconnection). In these circumstances the VSC will not function. The VSC helps to prevent the vehicle from slipping sideways as a result of a strong front wheel skid or a strong rear wheel skid during cornering. The normal braking system is unaffected.
    Remedy:
    Recall vehicles that are likely to be affected and inspect. If necessary replace the Yaw rate sensor.
  • Announcement date:
    05/05/2004
    Recalls number:
    R/2004/066
    VIN start:
    SB1DR56L-0E001128
    VIN end:
    SB1DR56L-0E041829
    Car Build Date:
    15/01/2003 - 05/11/2003
    Concern:
    Steering - Wear Of The Intermediate Shaft Spline
    Defect:
    It is possible on certain Avensis models fitted with Electric Motor assisted Power Steering (EMPS) that the intermediate steering shaft was incorrectly assembled this can result in premature wear of the shaft splines. This is identified by the abnormal noise produced however if the vehicle continues to be driven in this condition it may become difficult or in the worst case impossible to steer.
    Remedy:
    Inspect and if necessary replace the intermediate steering shaft.
  • Announcement date:
    05/05/2004
    Recalls number:
    R/2004/066
    VIN start:
    SB1BR56L-0E001019
    VIN end:
    SB1BR56L-0E042156
    Car Build Date:
    15/01/2003 - 05/11/2003
    Concern:
    Steering - Wear Of The Intermediate Shaft Spline
    Defect:
    It is possible on certain Avensis models fitted with Electric Motor assisted Power Steering (EMPS) that the intermediate steering shaft was incorrectly assembled this can result in premature wear of the shaft splines. This is identified by the abnormal noise produced however if the vehicle continues to be driven in this condition it may become difficult or in the worst case impossible to steer.
    Remedy:
    Inspect and if necessary replace the intermediate steering shaft.
  • Announcement date:
    05/05/2004
    Recalls number:
    R/2004/066
    VIN start:
    SB1ER56L-0E001007
    VIN end:
    SB1ER56L-0E041908
    Car Build Date:
    01/01/1970 - 01/01/1970
    Concern:
    Steering - Wear Of The Intermediate Shaft Spline
    Defect:
    It is possible on certain Avensis models fitted with Electric Motor assisted Power Steering (EMPS) that the intermediate steering shaft was incorrectly assembled this can result in premature wear of the shaft splines. This is identified by the abnormal noise produced however if the vehicle continues to be driven in this condition it may become difficult or in the worst case impossible to steer.
    Remedy:
    Inspect and if necessary replace the intermediate steering shaft.
  • Announcement date:
    26/08/2003
    Recalls number:
    R/2003/125
    Car Build Date:
    08/03/2003 - 17/03/2003
    Concern:
    Possible Malfunction Of Curtain Shield Airbag
    Defect:
    The crimping connector of the inflator cartridge may be incorrectly assembled with the curtain airbag on certain vehicles. In the event of airbag activation full deployment of the curtain shield cannot be guaranteed due to this condition.
    Remedy:
    Replace the curtain shield airbag.
  • Announcement date:
    26/08/2003
    Recalls number:
    R/2003/126
    Car Build Date:
    15/01/2003 - 14/03/2003
    Concern:
    Possible Imbalance Under Heavy Braking.
    Defect:
    The brake pipes leading into the ABS actuator may have been incorrectly positioned. This could cause an imbalance in performance under heavy braking.
    Remedy:
    Check and reposition the brake pipes if necessary.
  • Announcement date:
    30/09/2002
    Recalls number:
    R/2002/024
    VIN start:
    To be advised
    Car Build Date:
    01/02/1999 - 30/07/2000
    Concern:
    Car Spoiler May Become Detached
    Defect:
    There is a possibility that the car spoiler may become loose or detached.
    Remedy:
    Recall affected vehicles to revise spoiler fixing method to bolts.
  • Announcement date:
    11/07/2002
    Recalls number:
    R/2002/099
    VIN start:
    SB153BBN00E000020 SB164BBN00E000020 SB172BBN00E000020
    VIN end:
    SB153BBN00E014251 SB164BBN00E014251 SB172BBN00E014251
    Car Build Date:
    10/07/2000 - 28/06/2001
    Concern:
    Possibility Of Fuel Leak
    Defect:
    There is a possibility that excessive residual stress remains on the check valve of the fuel pump during the assembly process. If the vehicle is driven with the residual stress the check valve may leak fuel.
    Remedy:
    Recall affected vehicles to re-tighten the fuel pump check valve and replace the relevant fuel pipe to protect against stress fracture.
Step 3 - Contact your nearest dealer

Enter your postcode to see your nearest franchised dealer: